SECTION 1. IDENTIFICATION
Product Identifiers: All applicable American Elements product codes for CAS #593-29-3
Relevant identified uses of the substance: Scientific research and development
Supplier details:
American Elements
10884 Weyburn Ave.
Los Angeles, CA 90024
Tel: +1 310-208-0551
Fax: +1 310-208-0351
Emergency telephone number:
Domestic, North America +1 800-424-9300
International +1 703-527-3887
SECTION 2. HAZARDS IDENTIFICATION
GHS Classification
Physical Hazards: Not Classified
Health Hazards:
Skin irritiation: Category 2
Eye irritation: Category 2
Acute aquatic toxicity: Category 1
Signal Word: Warning
Hazard Statement:
Causes skin irritation
Causes serious eye irritation
Very toxic to aquatic life
Precautionary Statement:
Prevention
Wash skin thoroughly after handling.
Wear protective gloves/protective clothing/eye protection/face protection.
Avoid release to the environment
Response
IF ON SKIN: Wash with plenty of soap and water.
Specific treatment (see first aid measures on this label).
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.
If skin irritation occurs: Get medical advice/attention.
If eye irritation persists: Get medical advice/attention.
Take off contaminated clothing and wash before reuse.
Disposal
Dispose of contents/ container to an approval waste disposal plan.
Note: Concentrated dust may present an explosive hazard.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Product / CAS Number:
Potassium Stearate Powder / 593-29-3
SECTION 4. FIRST AID MEASURES
If inhaled: Remove to fresh air. Get medical attention for any breathing difficulty
In case of skin contact: Wash with clean water. Get medical advice if needed.
In case of eye contact: Wash thoroughly with running clean water. Get medical advice if irritation
develops.
If swallowed: Rinse mouth with water. Seek medical advice.
Acute and delayed symptoms: To the best of our knowledge, the chemical, physical and toxicological properties have not been thoroughly investigated.
First aid and notes for physicians: No data available
SECTION 5. FIREFIGHTING MEASURES
Flash Point: n/a
Suitable extinguishing media: Carbon dioxide, dry chemical powder, alcohol foam, water spray.
Water or foam may cause frothing.
Unsuitable extinguishing media : Water jet
Special hazards arising from the substance or mixture: Carbon monoxide and carbon dioxide and
Potassium oxides.
Advice for firefighters: In the event of a fire, wear full protective clothing and approved self-contained
breathing apparatus. Fight fire from a safe distance or protected location. Under
certain conditions a dust cloud of calcium stearate can explode when ignited by a
spark, flame or other ignition source. Must avoid generating dust to minimize risk
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal protective equipment:
Eye - Wear appropriate protective safety glasses
Skin – Wear appropriate protective gloves and clothing. Put on an appropriate respirator
Containment: Keep unnecessary personnel away. Eliminate all sources of ignition.
Do not allow the spilled product to enter sewers or open waterways
Clean-up Procedures: Dust deposits should not be allowed to accumulate on surfaces, as these may form
an explosive mixture if they are released into the atmosphere in sufficient concentration. Avoid the
generation of dust during the clean-up. Vacuum spills or cover with damp sand or saw-dust if sweep. No sparking tools should be used
SECTION 7. HANDLING AND STORAGE
Handling: Open packaging bag carefully, avoid spillage and dust formation and control ignition sources.
Use this product with adequate ventilation. Wash hands after handling.
Storage: Store in cool, dry place to avoid the effects of heat and moisture. Keep container tightly closed and properly labeled. Avoid exposure to sunlight, heat and spark. Ground all equipment containing material.
Minimize dust generation and accumulation. Routine housekeeping should be instituted to ensure that dusts do not accumulate on surfaces. Dry powders can build static electricity charges when subjected to the friction of transfer and mixing operations. Provide adequate precautions, such as electrical grounding and bonding, or inert atmospheres.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure limit: ACGIH TLV: TWA 10mg/m3 (Total),
Engineering controls: General room ventilation plus local exhaust at points of
emission to maintain levels of airborne contaminants
below exposure limits.
Personal protective equipment
Respiratory: An appropriate dust respirator. Should be used as a
precautionary measure where airborne contaminants
may occur.
Eye: Safety glasses. A face-shield, if the situation requires.
Hand: Protective gloves
Body: Overall or dust cloth, change daily.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Fine, white powder, granule
Odor: Slight fatty acid odor
Odor threshold: Data not available
pH (water slurry at 25°C): Data not available
Melting point (°C): > 200⁰C
Initial boiling point and boiling range: Data not available
Flash point: Data not available
Evaporation rate: Not applicable
Flammability: Non-flammable but combustible
Lower flammable (Explosive) limit: Data not available
Vapor Pressure: Not applicable
Solubility: Soluble in hot water
Relative density: 0.95 – 1.15
Vapor density: Data not available
Octanol / water partition coefficient: Data not available -
Decomposition temperature: Data not available
Viscosity: Not applicable
SECTION 10. STABILITY AND REACTIVITY
Chemical stability: Stable under normal condition of storage & transport
Conditions to avoid: Incompatible materials, static charge, sparks, heat and other ignition sources,
generation of dust
Hazardous reactions: Decomposed by acids, oxidizing agents and alkalies
Decomposition products: Carbon monoxide, carbon dioxide and calcium oxide fume
SECTION 11. TOXICOLOGICAL INFORMATION
Routes of exposure: Can occur through inhalation, ingestion and eye or skin contact.
Acute health effects
Eye contact: Causes serious eye irritation.
Skin contact: Skin irritation.
Inhalation: May cause respiratory tract irritation.
Ingestion: May be harmful if swallowed.
Chronic health effects: Long term exposures to high concentration of dust may cause increased mucous flow in the nose and respiratory system airways. This condition usually disappears after exposure ceases.
Carcinogenicity: No information available.
Reproductive toxicity: No information available.
Mutagenicity: No information available.
SECTION 12. ECOLOGICAL INFORMATION
Aquatic and terrestrial Ecotoxicity: Very toxic to aquatic life.
Persistence and degradability: No information available.
Bioaccumulation: Not information available.
Mobility in soil: No information available.
The product should be prevented from entering drains, sewers, streams etc.
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal method: Dispose of waste in accordance with local regulations and acts. Contaminated
packaging must be treated in the same manner as the product itself
Precautions for disposal: Prevent material from entering drains, sewers, streams etc.
SECTION 14. TRANSPORT INFORMATION
UN No.: Not regulated
UN proper shipping name: Not regulated
Transport hazard class: Not regulated
Packing group: N/A
Special shipping instructions: N/A
SECTION 15. REGULATORY INFORMATION
AICS, DSL, ENCS, PICCS On the inventory list
California Proposition 65: To the best of our knowledge, this product contains no levels of listed
substances, which the state of California has found to cause cancer, birth defects or other reproductive effects.
16. OTHER INFORMATION
Safety Data Sheet according to Regulation (EC) No. 1907/2006 (REACH). The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The information in this document is based on the present state of our knowledge and is applicable to the product with regard to appropriate safety precautions. It does not represent any guarantee of the properties of the product. American Elements shall not be held liable for any damage resulting from handling or from contact with the above product. See reverse side of invoice or packing slip for additional terms and conditions of sale. COPYRIGHT 1997-2022 AMERICAN ELEMENTS. LICENSED GRANTED TO MAKE UNLIMITED PAPER COPIES FOR INTERNAL USE ONLY.
